A c3/passat 2007 came into my place and the ABS module lost its coding without any reason.
Initially the code was 000001, I did some research and tried several codes copied from autoscans but none of them worked, (control module incorrectly coded).
The best and fastest way to find a solution is doing the SVM directly with a dealer but if you don’t want this, Rosstech has support for licenced interfaces.
So I did an autoscan of the passat (which is attached), and was told the coding: 46523
The “control module incorrectly coded” was gone but now the module was asking for a vacuum sensor “02543 Vacuum sensor for brake booster” but my passat wasnt equipped with that sensor.
The 46523 in binary would be 1011010110111011
The most significant bit in that binary number is 32768, not 8192….. so the correct would be 46523-32768=13755
decimal to binary
46523d=1011010110111011b
each digit has its value (check binary to decimal conversion). the one at the very right is the least significant bit and the one at the very left is the most significan bit (MSB)
The image ends with 8th digit = 128 but the 16th digit would equal 32768….. and disable it would mean change the binary number to 0 0 1 1 0 1 0 1 1 0 1 1 1 0 1 1… and than number in decimal is 13755
13755 worked perfectly, so for sure the most significant bit enables or disables the needing of that sensor.
Hope it helps
Attachment: Autoscan data throgh VAG-COM cable
——————————————————————————–
——————————————————————————–
Chassis Type: 3C0
Scan: 01 02 03 08 09 15 16 17 19 1C 25 42 44 46 52 53 56 62 72
VIN: WVWAK73C77P019353 Mileage: 60150km/37375miles
00-Steering Angle Sensor — Status: OK 0000
01-Engine — Status: OK 0000
02-Auto Trans — Status: Malfunction 0010
03-ABS Brakes — Status: Malfunction 0010
08-Auto HVAC — Status: Malfunction 0010
09-Cent. Elect. — Status: Malfunction 0010
15-Airbags — Status: Malfunction 0010
16-Steering wheel — Status: OK 0000
17-Instruments — Status: OK 0000
19-CAN Gateway — Status: Malfunction 0010
1C-Position Sensing — Status: OK 0000
25-Immobilizer — Status: OK 0000
42-Door Elect, Driver — Status: OK 0000
44-Steering Assist — Status: Malfunction 0010
46-Central Conv. — Status: OK 0000
52-Door Elect, Pass. — Status: OK 0000
53-Parking Brake — Status: Malfunction 0010
56-Radio — Status: Malfunction 0010
62-Door, Rear Left — Status: Malfunction 0010
72-Door, Rear Right — Status: OK 0000
——————————————————————————-
Address 01: Engine Labels: 06F-907-115-AXX.lbl
Part No SW: 3C0 907 115 P HW: 8P0 907 115 B
Component: 2.0l R4/4V TFSI 0030
Revision: 5BH16— Serial number: VWZCZ000000000
Coding: 0404010A19070160
Shop #: WSC 36090 993 55914
VCID: 2D55F94BB49D7070BA3
No fault code found.
Readiness: 0110 0101
——————————————————————————-
Address 02: Auto Trans Labels: 09G-927-750.lbl
Part No SW: 09G 927 750 FP HW: 09G 927 750 FP
Component: AQ 250 6F 0931
Revision: 00H38000 Serial number:
Coding: 0000072
Shop #: WSC 00028 028 00001
VCID: 8403FCEFC797D13885D
2 Faults Found:
01317 – Control Module in Instrument Cluster (J285)
004 – No Signal/Communication – Intermittent
Freeze Frame:
01314 – Engine Control Module
008 – Implausible Signal – Intermittent
Freeze Frame:
Fault Status: 00101101
Fault Priority: 2
Fault Frequency: 27
Reset counter: 0
Mileage: 0 km
Time Indication: 0
——————————————————————————-
Address 03: ABS Brakes Labels: 3C0-614-095-C2.clb
Part No SW: 3C0 614 095 S HW: 3C0 614 095 S
Component: ESP 440 C2 H015 0004
Revision: H015 Serial number: 0667589281
Coding: 0000000
Shop #: WSC 00993 993 00012
VCID: 326FEA37ADA32F88E71
2 Faults Found:
01044 – Control Module Incorrectly Coded
000 – –
Freeze Frame:
Fault Status: 01100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 75
Mileage: 60153 km
Time Indication: 0
Date: 2012.08.18
Time: 02:51:55
00778 – Steering Angle Sensor (G85)
005 – No or Incorrect Basic Setting / Adaptation
Freeze Frame:
Fault Status: 01100000
Fault Priority: 2
Fault Frequency: 1
Reset counter: 75
Mileage: 60153 km
Time Indication: 0
Date: 2012.08.18
Time: 02:51:55
——————————————————————————-
Address 08: Auto HVAC Labels: 3C0-907-044.lbl
Part No SW: 3C0 907 044 AF HW: 3C0 907 044 AF
Component: ClimatronicPQ46 050 0505
Revision: 00050005 Serial number: 00000000000000
Shop #: WSC 00000 000 00000
VCID: 65C5416BACED8830B23
2 Faults Found:
00457 – Control Module for Network (J519)
013 – Check DTC Memory – Intermittent
Freeze Frame:
Fault Status: 00111101
Fault Priority: 5
Fault Frequency: 1
Reset counter: 107
Mileage: 60059 km
Time Indication: 0
Date: 2012.08.14
Time: 00:02:50
01317 – Control Module in Instrument Cluster (J285)
004 – No Signal/Communication – Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 5
Fault Frequency: 3
Reset counter: 114
Mileage: 60059 km
Time Indication: 0
Date: 2012.08.14
Time: 00:05:08
——————————————————————————-
Address 09: Cent. Elect. Labels: 3C0-937-049-23-H.lbl
Part No SW: 3C0 937 049 Q HW: 3C0 937 049 Q
Component: Bordnetz-SG H46 1501
Revision: 00H46000 Serial number: 00000005802756
Coding: 05840F0340041A00470000000F00000000085D435C0000
Shop #: WSC 00028 028 00001
VCID: 3779DB2346C1CAA0D0F
Subsystem 1 – Part No: 3C1 955 119 Labels: 1KX-955-119.CLB
Component: Wischer VW461 012 0503
Coding: 00063445
Shop #: WSC 00028
3 Faults Found:
01800 – Light Switch (E1)
008 – Implausible Signal – Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 3
Fault Frequency: 1
Reset counter: 114
Mileage: 60136 km
Time Indication: 0
Date: 2012.08.16
Time: 03:55:00
Freeze Frame:
ON
Voltage: 12.10 V
ON
ON
OFF
OFF
OFF
00979 – Lamp for Low Beam; Right (M31)
010 – Open or Short to Plus – Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 1
Fault Frequency: 1
Reset counter: 114
Mileage: 60136 km
Time Indication: 0
Date: 2012.08.16
Time: 03:55:00
Freeze Frame:
ON
Voltage: 12.15 V
ON
ON
OFF
OFF
OFF
01341 – Control Module in Instrument Panel On Comfort CAN (J285)
004 – No Signal/Communication – Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 114
Mileage: 0 km
Time Indication: 0
Freeze Frame:
ON
Voltage: 12.15 V
ON
ON
OFF
OFF
OFF
——————————————————————————-
Address 15: Airbags Labels: 3C0-909-605.lbl
Part No SW: 3C0 909 605 J HW: 3C0 909 605 J
Component: 0D AIRBAG VW8 029 2521
Revision: 09029000 Serial number: 003A2PBEAADC
Coding: 0012356
Shop #: WSC 00028 028 00001
VCID: 2D55F94BB49D7070BA3
1 Fault Found:
01317 – Control Module in Instrument Cluster (J285)
004 – No Signal/Communication – Intermittent
——————————————————————————-
Address 16: Steering wheel Labels: 3C0-953-549-SW20.lbl
Part No SW: 3C0 953 549 E HW: 3C0 953 549 E
Component: J0527 0015
Revision: 00005000 Serial number: 3C5953507P
Coding: 0002111
Shop #: WSC 00028 028 00001
VCID: 2E57FE47B99B0B68839
Part No: XXXXXXXXXXX
Component: E0221 006 0080
No fault code found.
——————————————————————————-
Address 17: Instruments Labels: 3C0-920-xxx-17.lbl
Part No SW: 3C0 920 871 A HW: 3C0 920 871 A
Component: KOMBIINSTRUMENT VD1 1614
Revision: X0006000 Serial number: 00000000000000
Coding: 0007305
Shop #: WSC 14020 993 119778
VCID: 224F1A77FD43BF08171
No fault code found.
——————————————————————————-
Address 19: CAN Gateway Labels: 3C0-907-530-V1.clb
Part No SW: 3C0 907 530 C HW: 3C0 907 951 A
Component: Gateway 007 0040
Revision: 00007000 Serial number: 0700C066020C02
Coding: 3FFD0C04D21002
Shop #: WSC 00028 028 00001
VCID: 214D157BF845A4100EB
1 Fault Found:
00381 – Databus Instrument Cluster
004 – No Signal/Communication – Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 1
Fault Frequency: 2
Reset counter: 114
——————————————————————————-
Address 1C: Position Sensing Labels: 1Kx-919-xxx-1C.lbl
Part No SW: 3C0 919 965 HW: 3C0 919 965
Component: Kompass 005 0002
Revision: 00005000 Serial number: 1166279TQQT105
Shop #: WSC 00028 028 00001
VCID: EDD5B94BF41D30707A3
No fault code found.
——————————————————————————-
Address 25: Immobilizer Labels: 3C0-959-433-25.clb
Part No SW: 3C0 959 433 S HW: 3C0 959 433 S
Component: IMMO 041 0383
Revision: 00041000 Serial number: VWZCZ000000000
Shop #: WSC 131071 1023 2097151
VCID: 3A7FC21775D3D7C82F1
Part No: 3C0 905 861 F
Component: ELV 026 0380
3C0905861F ELV 026 0380
No fault code found.
——————————————————————————-
Address 42: Door Elect, Driver Labels: 1K0-959-701-MAX3.lbl
Part No SW: 1K0 959 701 Q HW: 1K0 959 793 M
Component: J386 TUER-SG FT 1123
Revision: 11006001 Serial number: 00000651968613
Coding: 0001207
Shop #: WSC 00028 028 00001
VCID: 3C73C40F7FE7E9F83DD
No fault code found.
——————————————————————————-
Address 44: Steering Assist Labels: 1Kx-909-14x-44.clb
Part No: 1K1 909 144 L
Component: EPS_ZFLS Kl.134 H07 1806
Shop #: WSC 36090 993 09388
VCID: 3463EC2F57B721B8F5D
1 Fault Found:
00778 – Steering Angle Sensor (G85)
000 – –
——————————————————————————-
Address 46: Central Conv. Labels: 3C0-959-433-46.clb
Part No SW: 3C0 959 433 S HW: 3C0 959 433 S
Component: KSG PQ46 ELV 041 0472
Revision: 00041000 Serial number: VWZCZ000000000
Coding: 13910F8001860E763004141FF08A0F0E087800
Shop #: WSC 35010 993 56106
VCID: 3A7FC21775D3D7C82F1
Component: Sounder n.mounted
Component: NGS n.mounted
Component: IRUE n.mounted
No fault code found.
——————————————————————————-
Address 52: Door Elect, Pass. Labels: 1K0-959-702-MAX3.lbl
Part No SW: 1K0 959 702 Q HW: 1K0 959 792 M
Component: J387 TUER-SG BT 1123
Revision: 11006001 Serial number: 00000038268616
Coding: 0001206
Shop #: WSC 00028 028 00001
VCID: 3D75C90B64FDE0F00A3
No fault code found.
——————————————————————————-
Address 53: Parking Brake Labels: 3C0-907-801-53.clb
Part No SW: 3C0 907 801 B HW: 3C0 907 801 B
Component: EPB VC8HC001 013 0001
Revision: 013
Coding: 0000013
Shop #: WSC 131071 1023 2097151
VCID: 214D157BF845A4100EB
2 Faults Found:
01087 – Basic Setting Not Performed
000 – – – MIL ON
Freeze Frame:
Fault Status: 11100000
Fault Priority: 4
Fault Frequency: 131
Reset counter: 65
Mileage: 39696 km
Time Indication: 0
Date: 2000.00.00
Time: 00:00:09
Freeze Frame:
Voltage: 12.84 V
Count: 170
00650 – Clutch Pedal Switch (F36)
010 – Open or Short to Plus – Intermittent
Freeze Frame:
Fault Status: 00101010
Fault Priority: 5
Fault Frequency: 11
Reset counter: 116
Mileage: 60152 km
Time Indication: 0
Date: 2012.08.17
Time: 14:24:53
Freeze Frame:
Voltage: 12.11 V
Count: 71
——————————————————————————-
Address 56: Radio Labels: 1K0-035-1xx-56.lbl
Part No SW: 1K0 035 180 H HW: 1K0 035 180 H
Component: Radio PM6 165 0018
Revision: 00165000 Serial number: VWZ5Z7F2088478
Coding: 0040401
Shop #: WSC 00028 028 00001
VCID: 2545016BEC6D4830723
1 Fault Found:
00668 – Supply Voltage Terminal 30
002 – Lower Limit Exceeded – Intermittent
Freeze Frame:
Fault Status: 00100010
Fault Priority: 3
Fault Frequency: 2
Reset counter: 116
Mileage: 60027 km
Time Indication: 0
Date: 2012.08.14
Time: 00:00:25
——————————————————————————-
Address 62: Door, Rear Left Labels: 1K0-959-703-GEN3.lbl
Part No SW: 1K0 959 703 Q HW: 1K0 959 795 J
Component: J388 TUER-SG HL 1113
Revision: 12004001 Serial number: 00000000214196
Coding: 0001168
Shop #: WSC 00028 028 00001
VCID: 3E77CE0769FBFBE8139
1 Fault Found:
01036 – Electric Window Thermal Protection Active; Rear Left
000 – – – Intermittent
Freeze Frame:
Fault Status: 00100000
Fault Priority: 7
Fault Frequency: 91
Reset counter: 104
Mileage: 59235 km
Time Indication: 0
Date: 2012.07.17
Time: 19:33:14
——————————————————————————-
Address 72: Door, Rear Right Labels: 1K0-959-704-GEN3.lbl
Part No SW: 1K0 959 704 Q HW: 1K0 959 794 J
Component: J389 TUER-SG HR 1113
Revision: 12004001 Serial number: 00000000215765
Coding: 0001168
Shop #: WSC 00028 028 00001
VCID: 3F89B3036EF1F2E018F
No fault code found.
End ———————————————————————
